Make us your home page
Instagram

Crystal River nuclear plant had flaw in safety procedures for over a decade

For more than a decade, Progress Energy Florida had a serious flaw in the safety procedures at its Crystal River nuclear plant.

If a major radiation leak had occurred, nearby communities might not have found out "in a timely manner," according to a U.S. Nuclear Regulatory Commission report issued to the nation's nuclear plants this week.

The NRC described the oversight as being of "low to moderate risk." It went on to say that a key part of the problem was a lack of training for use of the radiation detection equipment.

"Personnel were not knowledgeable about the design and operation of the radiation monitors," the commission report stated.

If a nuclear plant suffers a major radiation leak, the utility is required to have procedures for notifying the public so local authorities can order evacuations.

The procedure that Progress Energy wrote set the amount of radiation that would trigger a warning at a higher level than what the monitors could ever indicate, according to the NRC. So if the levels ever reached that high, it might not have been immediately clear to issue a warning to the community.

The problem could have been solved two ways: Rewrite the procedures to lower the radiation level that triggers a warning or use monitors that could measure the higher levels.

There was no indication that any radiation went undetected at Crystal River, threatening public health. But had there been a major release of radiation into the community, workers at the plant would have had to rely on their knowledge, experience or some other indicator rather than the monitoring system to warn local authorities to evacuate residents, the NRC said.

"There are other ways to get some information," NRC spokesman Roger Hannah said. But "they did not have equipment that could provide them information they needed."

Dave Lochbaum, a nuclear engineer with the Union of Concerned Scientists, said the problem is something Progress Energy Florida, the local subsidiary of Duke Energy that runs the plant, should have caught long ago. He said while it is fortunate that nothing happened, a major leak could have been devastating.

"When you hit a tree, it's a little late to find out you have a hole in your airbag," Lochbaum said.

The problem with the monitoring procedure and equipment at the Crystal River plant dates to June 2000, when Progress Energy Florida changed its procedures to meet new standards.

Progress Energy should have caught the problem earlier, according to federal regulators.

An NRC inspection report stated that "there were several opportunities to identify the . . . error" — two from the lesson of other plants in May 2008 and September 2010, and a third when Progress Energy revised its procedures in July 2010.

Nothing changed.

Heather Danenhower, a spokeswoman for the Crystal River plant, said Progress Energy Florida eventually fixed the problem when workers discovered that their procedures did not match the ability of their equipment to give proper warnings.

"This procedure issue did not pose a public health or safety concern," Danenhower said. "The plant would have needed to sustain multiple failures during a real emergency for this circumstance to have any impact.

"Since the plant went into service in 1977, it has never needed to declare a 'General Emergency' — the most significant of four emergency classifications."

The Nuclear Regulatory Commission notice sent out Tuesday identified two other plants with the same flaw, the Kewaunee nuclear plant in Wisconsin and the Prairie Island nuclear plant in Minnesota. Progress Energy Florida will not be fined for the oversight. The notice was a warning to other nuclear operators to avoid similar problems.

The Crystal River plant, which has been offline since 2009, is being retired.

During an upgrade project that fall to replace old steam generators, the nuclear plant reactor's 42-inch thick concrete containment building cracked.

Progress Energy attempted to bring the reactor back in service in March 2011 after repairing the first crack. However, more cracks were found in the containment building. Duke Power, which acquired Progress Energy last July, announced earlier this month that it would permanently close the plant.

Federal and state regulators are reviewing Duke Energy's plans for retiring the plant, the first nuclear plant to close in Florida and the first major one in the southeast United States.

Ivan Penn can be reached at ipenn@tampabay.com or (727) 892-2332.

Crystal River nuclear plant had flaw in safety procedures for over a decade 02/27/13 [Last modified: Thursday, February 28, 2013 9:46am]
Photo reprints | Article reprints

© 2017 Tampa Bay Times

    

Join the discussion: Click to view comments, add yours

Loading...
  1. City Council approves $5 million for Clearwater Marine Aquarium expansion

    Briefs

    CLEARWATER — The City Council on Thursday approved contributing $5 million to the Clearwater Marine Aquarium for its massive expansion project.

    Clearwater has agreed to contributed $5 million to the Clearwater Marine Aquarium 
's $66 million expansion project.. [ Clearwater Marine Aquarium] 


  2. Trigaux: Florida, Tampa Bay lagging in growth of their startups

    Economic Development

    The annual assessment of how entrepreneurs are doing across the country is out from the Kauffman Foundation — among the best watchers of the nation's startup scene. How do Florida and Tampa Bay fare?

    Lured by financial incentives, startup GeniusCentral relocated from Manatee County in 2015 to St. Petersburg, promising to creatye 40 new jobs. It took downtown space in an appropriately creative workpace for entrepreneurs. It did not last there, later moving back to less expensive space in Manatee. A new Kauffman Index report on entrepreneurship found that Florida is a good place to launch startups but a tougher place to grow them.
[SCOTT KEELER    |      TIMES]
  3. Pleasant dreams: sleep travel site gives high marks to Tampa airport

    Airlines

    TAMPA — Traveling might be considered closer to a nightmare than a dream for many. But that might be different for those who travel through Tampa International Airport. It was ranked the No. 3 overall best airport in North America by Sleeping in Airports, a travel site that tracks the best airports to catch some …

    Tampa International Airport was ranked as the No. 3 best overall airport by travel site Sleeping in Airports. | [Times file photo]
  4. Google parent leads $1B Lyft investment, deepening Uber rift

    Business

    SAN FRANCISCO — Google's parent company is throwing its financial support behind ride-hailing service Lyft, deepening its rift with market leader Uber.

    This  file photo shows a smartphone displaying the Lyft app.Google's parent company, Alphabet Inc., is throwing its financial support behind ride-hailing service Lyft, deepening its rift with market leader Uber. [Associated Press, 2016]
  5. ReliaQuest opens storefront in mock city of JA Biztown

    Economic Development

    TAMPA — ReliaQuest, a Tampa-based cybersecurity company, opened a "storefront" Wednesday at JA Biztown. The storefront is part of a mock city where students learn economic concepts and run businesses. About 20 real-life Tampa Bay companies sponsor storefronts that local students get to run for a day as part of a …

    ReliaQuest, a Tampa-based cybersecurity company, opened a "storefront" Wednesday at JA Biztown, a mock city where students learn to run businesses. | [MALENA CAROLLO, Times]